Product ID:AEROSHELL GREASE 7;SHELL CODE:70149
MSDS Date:04/05/1991
FSC:9150
NIIN:00-985-7245
MSDS Number: BGBTV

SHELL OIL COMPANY

HEALTH, SAFETY AND ENVIRONMENT
HOUSTON, TX 77210
US

Emergency Phone: 713-473-9461/ 713-241-2252

Info Phone: 713-241-4819

Preparer: J.C.WILLETT

Cage: 54527

SHELL OIL COMPANY

HOUSTON, TX 77210 US

Telephone: 800-231-6950

Cage: 54527

SYNTHETIC ESTER

CAS: 103-24-2

INORGANIC CLAY

CAS: 1302-78-9

RTECS: CT9450000

OSHA PEL 15 MG/M3 TOTAL DUST

ACGIH TLV: 10 MG/M3 TDUST;8990

FATTY ACID AMIDES

CAS: 68910-93-0

FATTY ACID AMIDES

CAS: 64754-98-9

OTHER COMPONENTS

LD50 LC50 Mixture:LD50 (ORAL RAT) 6-12 G/KG (ING # 1)
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE CONTACT: MAY BE MILDLY IRRITATING
TO THE EYES. SKIN CONTACT: PROLONGED OR REPEATED SKIN CONTACT MAY
CAUSE VARIOUS DISORDERS SUCH AS DERMATITIS, FOLLICULITIS OR OIL
ACNE. RELEASE DURING HIGH PRESSU RE USAGE MAY RESULT IN INJECTION
OF OILINTO THE SKIN CAUSING LOCAL NECROSIS. INHALATION: NO SPECIFIC
INFORMATION IDENTIFIED. INGESTION: NO SPECIFIC INFORMATION
IDENTIFIED. OTHER HEALTH EFFECTS: THIS S PECIFIC PRODUCT HAS NOT
BEEN TESTED IN LONG-TERM, CHRONIC EXPOSURE TESTS. LUBRICATING
GREASES ARE GENERALLY CONSIDERED TO BE OF A LOW ORDER OF ACUTE
TOXICITY TO HUMANS AND EXPERIMENTAL ANIMALS
Explanation of Carcinogenicity:THIS PRODUCT AND ITS COMPONENTS ARE NOT
CLASSIFIED AS CARCINOGENS BY INTERNATIONAL AGENCY FOR RESEARCH ON
CANCER (IARC), NATIONAL TOXICOLOGY PROGRAM (NTP) OR OCCUPATIONAL
SAFETY AND HEALTH ADMINISTRAT ION (OSHA).
Effects of Overexposure:MAY CAUSE EYE, SKIN & RESPIRATORY TRACT
IRRITATION. LOCAL NECROSIS IS EVIDENCED BY DELAYED ONSET OF PAIN
AND TISSUE DAMAGE A FEW HOURS FOLLOWING INJECTION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYES: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. CALL PHYSICIAN. SKIN: REMOVE CONTAMINATED CLOTHING AND WIPE
EXCESS OFF. WASH WITH SOAP AND WATER OR A WATERLESS HAND CLEANER,
FOLLOWE D BY SOAP AND WATER. DO NOT REUSE CLOTHING UNTIL THROUGHLY
CLEANED. IF MATERIAL IS INJECTED UNDER SKIN, GET MEDICAL ATTENTION
PROMPTLY TO PREVENT SERIOUS DAMAGE; DO NOT WAIT FOR SYMPTOMS TO
DEVELOP. I NHALED: MOVE VICTIM TO FRESH AIR. PROVIDE OXYGEN IF
BREATHING IS DIFFICULT. GETMEDICAL ATTENTION. INGESTION: DO NOT
INDUCE VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY UNLESS LARGE
QUANTITIES ARE I NGESTED. HOWEVER, GET MEDICAL ADVICE.

Flash Point Method:PMCC
Flash Point:=215.6C, 420.F
SYNTHETIC ESTER
Extinguishing Media:USE WATER FOG. DRY CHEMICAL OR CO2. DO NOT USE A
DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE REIGNITED ON
SURFACE OF WATER.
Fire Fighting Procedures:DO NOT ENTER CONFINED FIRE SPACE WITHOUT
PROPER PROTECTIVE EQUIPMENT INCLUDING A NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED CONTAINERS
SURROUNDING EQUIPMENT AND STRUCTURES WI TH WATER.
Unusual Fire/Explosion Hazard:NOT PROVIDED.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER. THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER
SECTION 311 OF THE CLEAN WATER ACT. SPILLS ENTERING SURFACE
WATERS,WATERCOURSES OR SEWERS WHICH CAUSE A SHEEN MUST BE REPORTED
-800-424-8802.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:MINIMIZE SKIN CONTACT. WASH WITH SOAP & WATER BEFORE
EATING, DRINKING, SMOKING OR USING TOILET FACILITIES. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE. PROPERLY DISPOSE OF
CONTAMINATED LEATHER ARTICLES (SHOES) THAT CAN NOT BE
DECONTAMINATED.

Respiratory Protection:NORMALLY NOT REQUIRED;USE NIOSH/MSHA APPROVED
RESPIRATOR FOR ORGANIC VAPORS/MIST IF APPLICABLE.
Ventilation:NORMAL ROOM VENTILATION
Protective Gloves:NEOPRENE RUBBER AS REQUIRED.
Eye Protection:SAFETY GLASSES RECOMMENDED.
Other Protective Equipment:USE OIL RESISTANT GLOVES AND OTHER CLOTHING
AS NEEDED TO MINIMIZE SKIN CONTACT. EYE WASH STATION,WORK CLOTHING
AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
DO NOT GET IN EYES OR ON CLOTHING.

HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE.
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILABLE.
Decomp Temp:Decomp Text:NOT PROVIDED.
Vapor Pres:NOT AVAILABLE.
Vapor Density:NOT AVAILA
Spec Gravity:NOT AVAILABLE.
Viscosity:NOT PROVIDED.
Evaporation Rate & Reference:NOT AVAILABLE.
Solubility in Water:INSOLUBLE
Appearance and Odor:BUFF COLORED,SMOOTH,BUTTERY GREASE,SLIGHT ODOR
Percent Volatiles by Volume:NOT PROVIDED

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:AVOID HEAT, SPARKS, AND/OR OPEN FLAME.
Hazardous Decomposition Products:A MIXTURE OF AIRBORNE SOLID, LIQUID
PARTICULATES & GASES (CO) WILL EVOLVE WHEN THIS MATERIAL UNDERGOES
PYROLYSIS OR COMBUSTION. CARBON MONOXIDE & UNIDENTIFIED ORGANIC
COMPOUNDS MAY FORM UPON COMBUSTION.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
IN COMPLIANCE WITH LOCAL/STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

SARA Title III Information:NOT REGULATED BY SARA TITLE III.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
INCLUDED ON EPA/THE TOXIC SUBSTANCE CONTROL ACT (TSCA) INVENTORY OF
CHEMICAL SUBSTANCES.
State Regulatory Information:BASED ON INFORMATION AVAILABLE TO SHELL,
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICAL SUBSTANCE LISTED ON A
CHEMICAL SPECIFIC STATE LIST.